|Title:||Tailstrike during go-around, McDonnell Douglas MD-11, E-ICDK, June 21, 1997|
|Micro summary:||This MD-11 experienced a tailstrike during a go-around.|
|Event Time:||1997-06-21 at 1222 HDT|
|Publishing Agency:||National Transportation Safety Board (NTSB)|
|Site of event:|
|Departure:||Halim Perdanakusuma International Airport, Jakarta, Indonesia|
|Destination:||Honolulu International Airport, Honolulu, Hawaii, USA|
|Airplane Type(s):||McDonnell Douglas MD-11|
|Flight Phase:||Missed Approach|
|Type of flight:||Revenue|
|Executive Summary:|| On June 21, 1997, at 1222 Hawaiian daylight time (HDT), a McDonnell Douglas MD-11 airplane, EI-CDK, operated by Garuda Indonesia as flight 800, was substantially damaged due to a tail strike during a go-around from an attempted autopilot autoland landing on Runway 8L at Honolulu International Airport (HNL), Hawaii. The flight crew completed a touch down and a go-around followed by an uneventful landing at 1235. Visual meteorological conditions prevailed and an instrument flight plan was filed. There were no injuries to the 289 passengers, 4 flight crew and 15 cabin attendants. The flight, a scheduled CFR Part 129 operation, originated at 2355 (June 20, HDT) from Jakarta, Indonesia.|
The captain provided a statement of circumstances on the day following the accident in which he stated that the first approach was flown as an autoland with flaps set 50 degrees. The approach and touchdown were normal. However, he indicated at touchdown that the airplane tended to pitch up and the nose tended to swing to the left. He disconnected the autopilot and the airplane was still "floating." He decided to initiate a go-around. The captain stated that upon initiating the go-around, he still observed the airplane drifting left. On the second landing, the captain stated that during the rollout, he needed to "force down the control" and required "additional downtrim to keep the nose wheel maintained on the ground."
Federal Aviation Administration (FAA) Air traffic control transcripts indicate the flight crew was given winds of 050 at 10 knots and landing clearance which they acknowledged at 1219:29. At 1222:26, the flight crew announced, "Indonesia eight hundred we go go-around," followed by a local controller acknowledgement. At 1222:31, the flightcrew stated, "Indonesia eight hundred we have a windshear on final." The local controller replied, "roger sir, no previous reports." The flight crew made no further mention of the event to air traffic controllers.
Runway inspection following the event indicated landing gear tire tracks and scrape marks of aluminum and ferrous metal transferred to the runway surface beginning adjacent taxiway Lima (4800 feet from the approach end) that extended in a left curving path about 1200 feet along the runway surface. The tire tracks and scrapes were consistent with the measurements of an MD-11 airplane. There were visible skid marks from the right main landing gear tires. Marks consistent with the track of the left landing gear tires and tail of the accident airplane continued along the curving path to exit the left side of the runway surface. A damaged runway edge light, metal scraps and aircraft antenna debris were located off the left side of the runway at the end of the scrape/drag marks. The total ground track extended about 1310 feet. Examination of the airplane revealed substantial damage to the aft lower fuselage and tailcone between fuselage stations 1700 and 2169. The aft pressure bulkhead was abraded and deformed about 45 inches across the bottom edge, wrinkling extended upward a maximum of about 7 inches.
An Aloha Airlines first officer located in an airplane on taxiway "A" parallel to the landing runway and directly facing in the landing airplane witnessed the accident from about 3000 feet away. He reported that following the landing, the nose began to come down as per a normal landing but then rotated to an unusually high nose attitude and held that attitude for approximately 3 seconds. It appeared that the tail missed hitting the runway by less than a foot. Then the airplane's nose again started coming down but within two seconds it again rotated to a high attitude. This time the tail struck the runway, and the airplane continued in a nose high attitude. It swerved left in the direction of the witnesses airplane while dragging the tail along the runway. The witness stated the airplane's nose continued raising so that it appeared that its main landing gear were off the ground, its tail still dragging, when it became airborne over the grass to the left of the runway. He observed the wings rocking as it lifted off with a great deal debris and grass filling the air. The airplane's wings wobbled several times as it turned to parallel the runway and slowly climbed out.
The airplane flight log signed off by the captain contained two entries regarding the accident : (a)Auto Land/APP, not satisfactory, disconnect AT/tends pitch up and swing to the left upon touchdown and (b) Tail strike, suspect tail strike.
The flight recorders were removed from the accident airplane with the assistance of personnel from the FAA Honolulu Flight Standards District Office and sent to the Safety Board's laboratory in Washington D.C. for readout. The recorded conversation from the CVR was found to be from a period of time following the event and not pertinent to the accident.
Garuda personnel also removed the QAR data tape from the airplane and carried it directly to Teledyne Controls facility in Los Angeles, California. Teledyne engineers reported to the Safety Board that they were unable to locate a synchronization pattern on the tape due to an airplane system malfunction and they were therefore unable to derive any useful information from the recording.
From the airplane load sheet, the reported landing weight at the time of the accident was 386,100 lbs. The balance was reported to be 27.5 MAC, and within the airplane performance envelope. The calculated Vref speed for a flaps 50 landing is 141 KIAS. The Douglas recommended approach speed is Vref +5 or Vref+wind. The autopilot/flight director speed command is not recorded on the DFDR.
The data from the DFDR indicated the following:
* The accident landing was a Dual Auto Land approach, speed on final approach was recorded between 147-154 KIAS. * Touchdown speed was recorded at 145 KIAS. * Airplane pitch attitude (3-5 degrees) and heading (081) were normal and constant in the moments before touchdown. * The initial touchdown peak "g" was 1.23. * The Autopilot (A/P) discrete indicates it was disengaged just prior to main landing gear wheel spin-up (as indicated by ground spoiler deployment). * Following A/P disengagement, the rudder deflection went to neutral removing the right rudder input of 4 to 8 degrees that the A/P had applied on the final approach. * Following A/P disengagement, the rudder deflection remained neutral and the airplane began approximately a 2 degrees per second yaw to the left. * During the 4 seconds between touchdown and wheel spin-up (as indicated by ground spoiler deployment) the pitch attitude decreased from 5 degrees airplane nose up (ANU) to 1 degree ANU. * The thrust reverse discrete for all engines indicate a transition to "transit" 4 seconds after touchdown. * The thrust reverse "transit" discrete for engine 3 indicated it went back to "stow" within 1 second. * The thrust reverse deploy discrete for engine 1 indicated deployment for about 4 seconds, engine 2 thrust reverse discrete indicated deployment for approximately 8 seconds. * Wheel spin-up took place approximately 4 seconds after the initial touchdown. * When the ground spoilers were deployed at wheel spin-up, a characteristic a nose-up pitching moment developed. * Following ground spoiler deployment, the airplane nose down (AND) elevator inputs were insufficient to counter the ANU pitching moment. The airplane attitude increased over a 5 second period from 1 degree toward 13 degrees ANU. ( a TAIL STRIKE occurs when the pitch attitude exceeds 11 degrees with the main gear on the ground) * Approximately 4 seconds after wheel spin-up the recorded throttle angles indicate selection of full thrust on all three engines. * Engine 3 N1 immediately began to increase but the N1 for engines 1 and 2 remained at idle until the thrust reverser discrete indications went from deploy to stow, 10 and 14 seconds later, respectively. * Following the increase in N1 on engine 3, the airplane began a left yaw that reached 14 degrees left of the runway heading. * At the lowest recorded airspeed of 112 KIAS, full right rudder (23-24 degrees) was applied. * Following the command for full thrust, the airplane pitch attitude remained from 11 to 13 degrees until it became airborne.). * The airplane became airborne at about 132 KIAS with engine 1 and 3 at full thrust (N1 110 percent), engine 2 was still accelerating for about 2 seconds more. However, at lift off the right rudder deflection was more than one half and the airplane rolled to the right reaching 26 degrees right wing down at a radar altimeter indication of 36 feet. Calculations indicate that the right wing tip was about 3 feet above the runway surface at this point.
The airplane was repaired by a Douglas Aircraft Company Recovery and Repair Group. It was returned to service on 18 August 1997. During return to service checks, the engine 1 reverser indicated a high running torque. The discrepancy was cleared with the replacement of a flex shaft on the right upper assembly, PN 121282-10. No other maintenance was required on the autopilot or flight control systems.
The FAA National Airways Systems Low-Level Windshear Alert (LLWAS) data at HNL samples wind information from of 6 sensors around the airfield. FAA specialists reviewed the data recorded from the sensors from 1200 to 1259 and reported that there were no windshears indicated during this time period.
The captain stated that he disconnected the autopilot during autoland upon touchdown because the airplane "tends pitch up and swing to the left". The captain did not give any indication that the thrust reverse system was partially activated during the accident landing and prior to his selection of go-around thrust. The Aircraft Accident Investigation Commission of Indonesia provided a review comment that an abnormal situation occurred at the moment that the autopilot was executing an autoland sequence, "where there was an indication of failure to control or correct the pitch up attitude and to maintain a proper runway heading." However, the FDR data indicates that the heading swing and nose up pitch changes took place after the auto pilot and autothrottle were manually disconnected during the autoland sequence and the airplane was being flown manually.
The MD-11 Flight Crew Operating Manual, Volume II, Landing Roll Procedure, contains the following note: Ground spoiler deployment causes nose up pitching moment. This effect is most noticeable at aft centers of gravity. It is important to check the nose up pitching tendency with forward pressure on the control column and smoothly lower the nose wheel to the runway.
The Boeing Douglas Products Division was asked to evaluate the FDR data from the accident airplane and to estimate the elevator column movement required to lower the nose during ground spoiler deployment at wheel spin up. A total of 25 degrees of AND elevator was available to the pilot. Douglas engineers determined that a brief increase to 15 degrees AND elevator for about 1/2 second would have been sufficient to avoid the tail strike. More elevator input or a faster pilot response would have resulted in a more improved attitude control. The FDR indicated AND elevator of about 4 to 8 degrees during spoiler deployment.
Douglas Aircraft Company conducted a Tail Strike Seminar for all operators on August 22, 1996. Garuda International representatives did not attend the seminar due to a cost reduction program within the company that precluded seminar attendence.
As a follow-up action to the August 1996 seminar, Douglas Aircraft Company sent a Flight Operations All Operator Letter, FO-AOL-11-129, dated September 13, 1996, to all operators on the subject, "MD-11 Tailstrikes." Garuda International personnel verified that this AOL was received. However, at the time of the accident, the crew had not been advised of the content of the AOL.
In June 1997, Douglas Aircraft Company sent a Tailstrike Avoidance Training Video to all MD-11 Operators. Garuda International had not received this training video at the time of the accident. On November 20, 1997, Douglas Aircraft Company sent a questionnaire to all MD-11 operators regarding the effectiveness of the tailstrike avoidance training material previously issued. Garuda International flight operations personnel responded on January 13, 1998, that they had received the video, incorporated it in their training programs, and that about 10 percent of their pilots had received the training to date.
Boeing Douglas Products Division Flight Operations Customer Service produced a Flight Operations Bulletin dated August 13, 1998, applicable to all DC-8, DC-9, C-9, MD-80, MD-90, DC-10, KC-10, and MD-11 airplanes. The bulletin (MD-11-97-06) stated that, "once thrust reversers have been deployed on landing, the landing must be completed because a successful go-around may not be possible."
Boeing Douglas Products Division Flight Operations published Temporary Revision 2-785, dated August 29, 1997, for the MD 11 Flight Crew Operating Manual, Volume II, Normal Procedures, LANDING ROLL PROCEDURE as follows:
WARNING AFTER REVERSE THRUST IS INITIATED, A FULL STOP LANDING MUST BE MADE.
This warning was also incorporated into the DC-10, MD-80 and MD-90 FCOMs in September 1997. Also, a review of all other Boeing transport aircraft operating manuals indicated that similar warnings existed in their manuals.
|Learning Keywords:||Operations - Tailstrike|
|Consequence - Damage - Airframe or fuselage|
|Close match:||Tail strike during take-off, Boeing 747-412 9V-SMT, flight SQ286, Auckland International Airport 12 March 2003|
|Tailstrike on takeoff, Serious incident occurring on November 29, 2002 at Dortmund Airport involving a Boeing 737-800|
|Tailstrike on takeoff, Boeing 757-204, G-BYAO|
|Tailstrike on landing, Airbus A320, C-GTDK|
|Tailstrike on landing, BAe 146-200, G-MANS|
|Uncommanded pitch-up, Airbus A320-214, G-OOAR|
|Tailstrike on landing, Boeing 747-267B, TF-ATD|
|Tail scrape on takeoff, Boeing 737-3YO, G-BWJA, 19 May 1997|
|Tailstrike on landing, Boeing 727-200, N12305, 8 December 1999 at 1112 hrs|
|Landed short, Loftleidir Icelandic Airlines, Inc., Douglas DC-8-61, John F. Kennedy International Airport, Jamaica, New York, June 23, 1973|
|Crash on runway in windshear, Allegheny Airlines, Inc., Douglas DC-9, N994VJ, Philadelphia International Airport, Philadelphia, Pennsylvania, June 23, 1976|
|Uncommanded roll, McDonnell Douglas MD-11F, June 2, 2002|
|Wake turbulence encounter between McDonnell Douglas MD-11 and Boeing 747, May 1, 1996|
|Bounced landing and tailstrike, McDonnell Douglas MD-11, November 4, 1994|
|Tailstrike during rejected takeoff, Airbus Industrie A300-600F, June 10, 2002|
|Tailstrike, Boeing 757-232, October 4, 1993|
|Tailstrike on landing, Boeing 757-24APF, December 25, 1994|
|Tailstrike on landing, Boeing 757-200, June 5, 2001|
|Tailstrike on landing, Airbus A300-600R, February 6, 1997|
|Tailstrike on landing, McDonnell Douglas DC-9-82, June 16, 2002|
|Tail strike during go-around, Boeing 727-227, November 15, 1993|
|Tail strike on landing, Lockheed L-1011, May 9, 2000|
|Tail strike on takeoff, Boeing 747-128, December 28, 2001|
|Tail strike on landing, A300-600ER, July 15, 1999|
|Tail strike on landing from FMS error, McDonnell Douglas MD-11, November 11, 1998|
|Tail strike on landing, Boeing 757-251, September 9, 2002|
|Tail strike during go-around, McDonnell Douglas MD-11F, September 19, 2004|
|Severe windshear, McDonnell Douglas DC-9-82 (MD-82), June 5, 1996|
|Runway incursion, two Boeing 737s at DFW, August 16, 2001|
|Over-rotation on landing, Airbus A300-600, December 15, 1997|
|Over-rotation on landing and tail strike, Lockheed L-1011, August 25, 1996|
|Hard landing and tail strike, McDonnell Douglas DC-9-51, June 14, 2000|
|Hard landing, McDonnell Douglas MD-88, July 27, 1993|
|Tailstrike on landing, McDonnell Douglas MD-11, HL-737, May 25, 1996|
|Tail strike on take-off and aircraft pitch-up on final approach, Air Canada, Airbus 330-343 C-GHLM, Frankfurt/Main Airport, Germany, 14 June 2002|
Accident Reports on DVD, Copyright © 2006 by Flight Simulation Systems, LLC. All Rights Reserved. All referenced trademarks are the property of their respective owners.www.fss.aero